Abstract

A new method for determining the heat transfer coefficient for air flowing steadily through beds of particles is presented. In this technique, a step change in the inlet air temperature is applied to a small test bed and temperature distributions in the bed and at the air outlet are sampled over a short time period. The convective heat transfer coefficient is determined using data from the convective heat transfer process in the bed where the analysis includes the partial differential equation that describes the transient energy storage in the particles within the bed. The analysis is performed for a short time duration when the temperature distribution in the particle bed is almost linear along the axis of the bed. This time period permits the most accurate determination of the heat transfer coefficient using the data. Using beds of spherical particles a new correlation is developed for the Nusselt number versus the Reynolds number (5<Redh<280) and includes the uncertainty bounds. This new correlation compares well with correlations developed by some other researchers for similar spherical particle beds.

1.
Travkin
,
V. S.
, and
Catton
,
I.
, 2001, “
Transport Phenomena in Heterogeneous Media Based on Volume Averaging Theory
,”
Adv. Heat Transfer
0065-2717,
34
, pp.
1
144
.
2.
Shah
,
R. K.
, and
London
A. L.
, 1978, “
Laminar Flow Forced Convection in Ducts
,”
Advances in Heat Transfer
,
Academic
,
New York
, Suppl. 1.
3.
Arpaci
,
V. S.
, and
Larsen
,
P. S.
, 1984,
Convection Heat Transfer
,
Prentice-Hall
,
Englewood Cliffs, NJ
.
4.
Whitaker
,
S.
, 1972, “
Forced Convection Heat Transfer Correlations for Flow in Pipes, Past Flat Plates, Single Cylinders, Single Spheres, and for Flow in Packed Beds and Tube Bundles
,”
AIChE J.
0001-1541,
18
(
2
), pp.
361
371
.
5.
Kaviany
,
M.
, 1995,
Principles of Heat Transfer in Porous Media
,
Springer-Verlag
,
New York
.
6.
Nie
,
X. D.
, 2010, “
Heat and Moisture Migration Within a Porous Urea Particle Bed
,” Ph.D. thesis, University of Saskatchewan, Saskatoon, SK, Canada.
7.
Baclic
,
B. S.
,
Heggst
,
P. J.
, and
Abou
,
H. Z. Z.
, 1986, “
Differential Fluid Enthalpy Method for Predicting Heating Transfer Coefficients in Packed Beds
,”
Proceedings of the Eighth International Heat Transfer Conference
, Vol.
5
, pp.
2617
2622
.
8.
Bulck
,
E. V.
, and
Klein
,
S. A.
, 1990, “
Single-Blow Test Procedure for Compact Heat and Mass Exchangers
,”
ASME J. Heat Transfer
0022-1481,
112
, pp.
317
322
.
9.
Wang
,
Y. H.
,
Simonson
,
C. J.
,
Besant
,
R. W.
, and
Shang
,
W.
, 2007, “
Transient Humidity Measurements-Part I: Sensor Calibration and Characteristics
,”
IEEE Trans. Instrum. Meas.
0018-9456,
56
(
2
), pp.
1074
1079
.
10.
Wang
,
Y. H.
,
Simonson
,
C. J.
,
Besant
,
R. W.
, and
Shang
,
W.
, 2007, “
Transient Humidity Measurements-Part II: Determination of the Characteristics of an Interactive Device
,”
IEEE Trans. Instrum. Meas.
0018-9456,
56
(
2
), pp.
1080
1086
.
11.
Abe
,
O. O.
,
Wang
,
Y. H.
,
Simonson
,
C. J.
,
Besant
,
R. W.
, and
Shang
,
W.
, 2006, “
Transient Temperature Measurements and Characteristics for Temperature Sensors and Energy Wheels
,”
ASHRAE Trans.
0001-2505,
112
(
2
), pp.
76
89
.
12.
Shang
,
W.
, and
Besant
,
R. W.
, 2008, “
Theoretical and Experimental Methods for the Sensible Effectiveness of Air-to-Air Energy Recovery Wheels
,”
HVAC&R Res.
,
14
, pp.
373
396
.
13.
Shang
,
W.
, and
Besant
,
R. W.
, 2009, “
Effectiveness of Desiccant Coated Regenerative Wheels From Transient Response Characteristics and Flow Channel Properties Part I: Development of Effectiveness Equations from Transient Response Characteristics. Part II: Predicting and Comparing the Latent Effectiveness of Dehumidifier and Energy Wheels using Transient Data and Properties
,”
HVAC and R Res.
1078-9669,
15
, pp.
329
365
.
14.
Nsofor
,
E. C.
, and
Adebiyi
,
G. A.
, 2001, “
Measurements of the Gas-Particle Convective Heat Transfer Coefficient in a Packed Bed for High-Temperature Energy Storage
,”
Exp. Therm. Fluid Sci.
0894-1777,
24
, pp.
1
9
.
15.
Nield
,
D. A.
, and
Bejan
,
A.
, 1992,
Convection in Porous Media
,
Springer-Verlag
,
New York
.
16.
Nie
,
X. D.
,
Besant
,
R. W.
, and
Evitts
,
R. W.
, 2008, “
An Experimental Study of Moisture Uptake and Transport in a Bed of Urea Particles
,”
Granular Matter
1434-5021,
10
, pp.
301
308
.
17.
Nie
,
X. D.
,
Evitts
,
R. W.
, and
Besant
,
R. W.
, 2008, “
Simulation of Moisture Uptake and Transport in a Bed of Urea Particles
,”
Ind. Eng. Chem. Res.
0888-5885,
47
, pp.
7888
7896
.
18.
Kar
,
K. K.
, and
Dybbs
,
A.
, 1982, “
Internal Heat Transfer Coefficients of Porous Metals
,”
Heat Transfer in Porous Media
,
J. V.
Beck
and
L. S.
Yao
, eds., ASME, Winter Meeting, Phoenix, AZ, 1982, HTD-Vol.
22
, pp.
81
91
.
19.
Kays
,
W. M.
, and
London
,
A. L.
, 1984,
Compact Heat Exchangers
,
McGraw-Hill
,
New York
.
20.
Peng
,
S.
,
Besant
,
R. W.
, and
Strathdee
,
G.
, 2000, “
Heat and Mass Transfer in Granular Potash Fertilizer With a Surface Dissolution Reaction
,”
Can. J. Chem. Eng.
0008-4034,
78
, pp.
1076
1086
.
21.
ASME
, 1990,
ANSI/ASME PTC 19.1–1985 Part 1. Instruments and Apparatus-Measurement Uncertainty
,
ASME
,
New York
.
You do not currently have access to this content.